Long-Term Aging Study of a Silicon Nitride Nanomechanical Resonator
Fuente:
arXiv
Enregistré dans:
| Auteurs principaux: | , , , , , , |
|---|---|
| Format: | Preprint |
| Publié: |
2024
|
| Sujets: | |
| Accès en ligne: | |
| Tags: |
Ajouter un tag
Pas de tags, Soyez le premier à ajouter un tag!
|
| _version_ | 1866916357312872448 |
|---|---|
| author | Stephan, Michel Bouchard, Alexandre Hodges, Timothy Green, Richard G. Koukoulas, Triantafillos Wu, Lixue St-Gelais, Raphael |
| author_facet | Stephan, Michel Bouchard, Alexandre Hodges, Timothy Green, Richard G. Koukoulas, Triantafillos Wu, Lixue St-Gelais, Raphael |
| contents | Short-term changes in the resonance frequency of silicon nitride (SiN) nanomechanical resonators can be measured very precisely due to low thermomechanical fluctuations resulting from large mechanical quality factors. These properties enable high-performance detection of quasi-instantaneous stimuli, such as sudden exposure to radiation or adsorption of mass. However, practical use of such sensors will eventually raise questions regarding their less-studied longer-term stability, notably for calibration purposes. We characterize aging of an as-fabricated SiN membrane by continuously tracking changes of its resonance frequency over 135 days in a temperature-controlled high vacuum environment. The aging behavior is consistent with previously reported double-logarithmic and drift-reversal aging trends observed in quartz oscillators. The aging magnitude (300 ppm) is also comparable to typical temperature compensated quartz oscillators (TCXO), after normalization to account for the greater importance of interfaces in our thin (90 nm) resonator, compared to several microns thick TCXOs. Possible causes of aging due to surface adsorption are investigated. We review models on how water adsorption and desorption can cause significant frequency changes, predominantly due to chemisorption stress. Chemical species adsorbed on the resonator surface are also identified by X-ray photoelectron spectroscopy (XPS). These measurements show a significant increase in carbon every time the sample is placed under vacuum, while subsequent exposure to air causes an increase in oxidated carbon. Developing models for the contribution of carbon and oxygen to the membrane stress should therefore be an important future direction. Other contaminants, notably alkaline and halide ions, are detected in smaller quantities and briefly discussed. |
| format | Preprint |
| id |
arxiv_https___arxiv_org_abs_2408_07612 |
| institution | arXiv |
| publishDate | 2024 |
| record_format | arxiv |
| spellingShingle | Long-Term Aging Study of a Silicon Nitride Nanomechanical Resonator Stephan, Michel Bouchard, Alexandre Hodges, Timothy Green, Richard G. Koukoulas, Triantafillos Wu, Lixue St-Gelais, Raphael Materials Science Short-term changes in the resonance frequency of silicon nitride (SiN) nanomechanical resonators can be measured very precisely due to low thermomechanical fluctuations resulting from large mechanical quality factors. These properties enable high-performance detection of quasi-instantaneous stimuli, such as sudden exposure to radiation or adsorption of mass. However, practical use of such sensors will eventually raise questions regarding their less-studied longer-term stability, notably for calibration purposes. We characterize aging of an as-fabricated SiN membrane by continuously tracking changes of its resonance frequency over 135 days in a temperature-controlled high vacuum environment. The aging behavior is consistent with previously reported double-logarithmic and drift-reversal aging trends observed in quartz oscillators. The aging magnitude (300 ppm) is also comparable to typical temperature compensated quartz oscillators (TCXO), after normalization to account for the greater importance of interfaces in our thin (90 nm) resonator, compared to several microns thick TCXOs. Possible causes of aging due to surface adsorption are investigated. We review models on how water adsorption and desorption can cause significant frequency changes, predominantly due to chemisorption stress. Chemical species adsorbed on the resonator surface are also identified by X-ray photoelectron spectroscopy (XPS). These measurements show a significant increase in carbon every time the sample is placed under vacuum, while subsequent exposure to air causes an increase in oxidated carbon. Developing models for the contribution of carbon and oxygen to the membrane stress should therefore be an important future direction. Other contaminants, notably alkaline and halide ions, are detected in smaller quantities and briefly discussed. |
| title | Long-Term Aging Study of a Silicon Nitride Nanomechanical Resonator |
| topic | Materials Science |
| url | https://arxiv.org/abs/2408.07612 |